Custom built expedition vehicle for sale.
EL YOLO CAMPER
For more info: [email protected]

El Yolo Information

This expedition vehicle was custom build in 2019 and allows you to travel year round without ever visiting a campground, traveling the roughest roads and through hot and cold weather environments. If you are looking for a vehicle to camp at RV parks, this is probably not for you (although you will get a lot of attention).

2007 Dodge Sprinter 3500 Cab Chassis 3.0 Liter 6 Cylinder Diesel, Automatic Transmission

Dimensions: Length: 22.7ft, Height: 10ft, Width: 7.2ft (with mirrors)

4x4 Conversion by Whitefeather California:

- Conversion completed in 2018
- Weight Certification after conversion:
o Front Axle: 6,000 lbs.
o Rear Axle: 7,280 lbs
o GVWR: 13,280lbs
- 6 Inch lift or additional clearing
- HD Welded sub frame replacing the OE subframe
- Manual hub locks
- 6,000 lbs load rated Dana 60 Super mono-beam front axle with rear axle appropriate gear ratio
- Fox Racing steering stabilizer
- Open front differential
- Front disc brakes (approx.. 36% bigger than OE Sprinter)
- 2 Speed manual shift NV271 Transfer Case ( low gear is a crawling gear with transmission in low also )
- Oversized front (1.375” diameter) Roadmaster chrome moly sway bar with greasable poly bushings
- Custom valved ( V4 )Fox Racing gas pressure front and rear shock absorbers
- 17 inch aluminum wheels, steel inside rear and spare wheels
- Dana Spicer front and rear drive shafts
- Steel rear lift blocks, Tri-8 rear u- bolts,
- Aluminum font bumper with black powder coat and dual driving light ports, with grille guard
- Pair KC / ProComp 6 inch off road driving lights with standalone wiring harness, mounted in Whitefeather front bumper
- Eaton E-Locker locking front differential with Lucas oil
- Tires size LT 275/65R18E front and spare and size LT285/65R18E rear
- Additional spare rear wheel and tire on matching wheel (two spare wheels)
Camper Box: Built by Twiga Travel Cars in the Netherlands, a high end builder of custom overland vehicles www.twigatravelcars.nl
- Measurements: Length: 13.6 Ft, Inside Height: 6 Ft,5Inches, Width: 7 Ft
- Camperbox completed in 2019
- This box is constructed with an aluminum frame with Twiga isolating panels© of 60 mm thick. These panels are mounted from the inside in order to guarantee no leakage and use thermal bridges. This construction is also to maintain maximal stiffness and insulation.
- 4 Outbound windows: One window sized 990mm x 600mm (RA-40) and three windows sized 990mm x 400mm (RA-35).
- 1 Outbound Skylight above sitting area: 990mm x 600mm (DR-40)
- All windows have extra fine mesh against bugs and black-out blinds
- Armored plates to cover windows and hatches for safe shipping
- Outbound entrance door with mosquito screen and three point lock mechanism for additional security: 550 x 1700 mm (DE-10)
- Electronics
o Victron isolation transformer 3600W for the car.
o Victron Multiplus 12/3000
o 2 Victron solar panels, each panel 295 Wp.
o 2 Victron panel loaders, meeting all demands.
o 2 AGM batteries, 12 Volts / 220 Ah, charged by Solar panels, while driving and shorepower.
o Color panel, to inform you by laptop and/or telephone on the status of the system.
o Shore power connection and cable (15 meters), including adaptor.
o TS 800 separation relays.
o Three outside light, one on each side and one on the back.
o 12 Volts fuses group.
o 220 Volts fuses group.
o Dimmable LED lighting throughout box
o Euro/American 220 Volt Sockets, 12 Volt sockets and USB sockets throughout box
- Water Supply system:
o 224 Liter/59 Gallon Water tank
o Shurflo Water pump
o 24 Liter water boiler either on electricity (water can be heated while driving) or by Webasto water heater (Diesel)
o Two greay water tanks (one for the shower area, one for the kitchen sink)
- Heating:
o Webasto Diesel Airflow 4KW heater (Airtop 40)
o Webasto water heater (Thermo Top E): This will heat water in boiler and waste water in grey water tanks
- Kitchen Appliance:
o Two burner propane cooktop: Dometic HBG 2335
o Propane Oven/Grill with light and rotating plate: Dometic OG 3000
o Fridge/Freezer: Isotherm
o Sink: Reginox
o Seagull Waterfilter
- Bathroom:
o Shower
o Sink
o Thetford Cassette Toilette 263CS
o Gebo Skylight
o Daewoo Mini-washer
- Queen size bed (when fully extended)
- Seating area for 5 people
- Big Outside Garage that fits 3 Bikes and outdoor accessories with light, USB and 12 Volt charger
- Additional Components:
o Retractable Steps to access camper box
o Retractable Steps to access roof rack
o Rear bumper
o Roofrack for two wheels and tyres with lifting system on the roof of the Sprinter
o Thule 5200 awning
o Built in ARB compressor
o Rear view camera
o Outdoor kitchen:
▪ Propane hookup for two burner stove/grill
▪ Water outlet
▪ Detachable kitchen counter
o Outside lights on both sides of the camper box and in the back
o 30 Gallon Additional Dieseltank
o Storage space with one propane bottle, upgradable to two bottles
o 3 Additional outside storage boxes for tools and accessories

Repairs and maintenance done since 2019:

March 13th, 2019: Mercedes Benz Dealer Netherlands, Mileage: 144,889
​Replace Steering angle sensor

May 7th, 2019: Mercedes Benz Dealer, Mileage: 146,299

1 Replace leaking intake silencer
2 Replace fuel filter
3 Replace air filter

May 9th, 2019: Mercedes Benz Dealer, Mileage: 146,329

1 Replace Torque Converter​
2 Sprinter Transmission service
3 Replace Intercooler
4 Oil and filter change